Evo Harley Davidson Oil Drain Plug Location

Twin cam under the motor you ll see 2 plugs one vertical and one horizontal.

Evo harley davidson oil drain plug location.

Screw the drain plug into the engine by hand then tighten it to 22 foot pounds using a 5 8 inch socket and a torque wrench. The horizontal bolt is the transmission drain screw. The oil drain is located behind the left sidecover. Be sure to achieve free play on the clutch cable to verify that you have proper.

Skip this step if your are working on an evolution equipped sportster softail or dyna motorcycle. The picture of the plug s location is in next step. Remove the drain plug washer and replace it with a new washer. Push the drain plug into the oil drain hose and tighten.

Drain the engine oil into an oil pan. Harley clutch adjustment on a softail or dyna. Dyna and touring models have their oil drain plugs under the transmission housing. The vertical bolt is the oil drain plug.

Find the drain plug in the bottom side of the chain case. The most common way oil cases become damaged is from harley drain plug over tightening. There you will see a hose with a metal plug in the end held in place by a clamp. Loosen the clamp remove the plug and oil will drain from the tank.

Unlike newer softails where the transmission drain plug is located between the two softail shocks underneath the tranny the older evo softail transmission 1993 fxsts drain plug is located on. If the engine oil or transmission oil drain plug allocation becomes stripped on a touring model the entire oil pan may need to be replaced. You might also enjoy. This holds true for both twin cams and m8 touring models.

My 1995 1340 evo roadking oil light stays on at idle when the engine is hot i ve chenged the oil and filter using genuine harley davidson changed the oil pressure switch and even done a full engine flush with 4 litres of flush oil which as made the oil light stay on until 1200 rpm s before i flushed the system the light would go off at a round 1000 1100 rmp s. On softail models the engine oil drain plug is under the right side of the motorcycle s frame near the rear wheel. Harley davidson sportster at the back oil tank drain hose connected to a nipple on the frame with a hose clamp. Place your drain pan under the plug.

You will need to use a t 30 to turn the plug out. Harley davidson oil change for your evolution engine. Step one is find the drain plugs. Bob teaches you how to adjust the clutch and primary chain on your harley softail or dyna model.